Microalgae and cyanobacteria are unicellular microorganism that contain high-added-value compounds. To make their extraction economically feasible, the biorefinery concept is the only solution. In this study, the residues resulting from lipid or protein extraction from Arthrospira platensis biomass were valorized by catalytic pyrolysis using ZSM5 zeolite or amorphous silica−alumina as catalyst. The reaction was performed in a quartz reactor, and the catalysts were placed in a fixed bed, to force the reaction gases to pass through it. The reaction products were analyzed by FTIR and GC−MS analyses. The reaction gases and liquids obtained from the extraction residues had higher hydrocarbon contents compared with the untreated biomass. Moreover, the pyrolysis of biomass after protein extraction led to fractions with lower nitrogenated component contents, while that after lipid extraction to fractions with lower oxygenated component contents. This study showed that the pyrolysis process cou... [more]

This study examined the feasibility of using non-sterilized swine wastewater for lipid production by an isolated microalga, Scenedesmus rubescens. Different dilution ratios using municipal wastewater as a diluent were tested to determine the suitable levels of microalgal growth in the wastewaters, its nutrient removal, and its lipid production. The highest lipid productivity (8.37 mg/L/d) and NH4+ removal (76.49%) were achieved in swine wastewater that had been diluted to 30 times using municipal wastewater. Various bacteria coexisted in the wastewaters during the cultivation of S. rubescens. These results suggest the practical feasibility of a system to produce lipids from swine wastewater by using microalgae.

Molasses is a highly dense and refined byproduct produced in the sugarcane industry, and it contains high amounts of degradable compounds. Through bioconversion, these compounds can be transformed into renewable products. However, the involved biological process is negatively influenced by the high chemical oxygen demand (COD) of molasses and ion concentration. The co-digestion of molasses with rice-alcohol wastewater (RAW) was compared with its mono-digestion at an increasing organic loading rate (OLR). Both processes were assessed by detecting the COD removal rate, the methane contents of biogas, and the structure and composition of microbial communities at different stages. Results showed that the co-digestion is stable up to a maximum OLR of 16 g COD L−1 d−1, whereas after the acclimatization phase, the mono-digestion process was disturbed two times, which occurred at a maximum OLR of 9 and 10 g COD L−1 d−1. The volatile fatty acids (VFAs) observed were 2059.66 mg/L and 1896.9 mg/L... [more]

The energy contained in wastewaters has been identified as a promising sustainable energy resource that could be harvested by using microbial fuel cells (MFC). When dealing with real wastewaters, the MFCs should be able to manage high flow rates and flow rates fluctuations. In this work, the short-term effects of the influent flow rate variations on the performance of a microbial fuel cell has been studied. With this aim, the influent flow rate was stepwise increased from 0.72 to 7.2 L/d and then stepwise decreased. The obtained results indicate that, on the one hand, an increase in the influent flow rate leads to higher chemical oxygen demand removal rates up to 396 g/(L/d) and higher electric power generation almost 18 mW/m2, but to lower coulombic efficiencies. On the other hand, the reduction of the flow rate increases the coulombic efficiencies, as well as the percentage of chemical oxygen demand removed, but decreases electric power generation. In the short-term, the exposition t... [more]

Development of economical and environment-friendly Microbial Fuel Cells (MFCs) technology should be associated with waste management. However, current knowledge regarding microbiological bases of electricity production from complex waste substrates is insufficient. In the following study, microbial composition and electricity generation were investigated in MFCs powered with waste volatile fatty acids (VFAs) from anaerobic digestion of primary sludge. Two anode sizes were tested, resulting in organic loading rates (OLRs) of 69.12 and 36.21 mg chemical oxygen demand (COD)/(g MLSS∙d) in MFC1 and MFC2, respectively. Time of MFC operation affected the microbial structure and the use of waste VFAs promoted microbial diversity. High abundance of Deftia sp. and Methanobacterium sp. characterized start-up period in MFCs. During stable operation, higher OLR in MFC1 favored growth of exoelectrogens from Rhodopseudomonas sp. (13.2%) resulting in a higher and more stable electricity production in... [more]

Maximizing the internal carbon sources in raw wastewater was found to be an alternative option to alleviate the financial burden in external carbon sources (ECS) addition to the biological nutrient removal (BNR) process. Based on previous studies on particulate recovery via fine-sieving technologies, alkali pretreatment was used to improve the short-chain fatty acid (SCFA) production from the fine-sieving fractions (FSF). Hydrolysis performance and methane production were monitored to evaluate the reasons for the SCFA boost. Besides, the microbial community structure was evaluated by high-throughput sequencing. Furthermore, mass balance and financial benefits were preliminarily estimated. The results showed that alkali pretreatment effectively promoted the generation of SCFAs with 234 mg/g volatile suspended solids (VSS), almost double that of the control test. This was partially attributed to the efficient hydrolysis, with soluble polysaccharides and protein increased by 2.1 and 1.2 t... [more]

This article presents the results of a three-year experiment involving a multi-criteria evaluation (productivity, economic and energy balance) of the effectiveness of nitrogen (N) and sulfur (S) fertilization in different cultivars of winter oilseed rape (open-pollinated, semi-dwarf hybrid, long-stem hybrid) grown in north-eastern (NE) Poland. The yield of the semi-dwarf cultivar was 11% lower than the yield of the long-stem hybrid cultivar and 18% higher than the yield of the open-pollinated cultivar. In all cultivars, N fertilization improved yields up to a rate of 180 kg ha−1 and up to a rate of 230 kg ha−1 in years with low precipitation in spring and summer. Seed yield increased in all cultivars in response to S fertilization at 40 kg ha−1. Higher rates of N fertilizer decreased the content of crude fat and glucosinolates (GLS) and increased the concentration of total protein in all cultivars. Sulfur fertilization increased the content of total protein (in long-stem cultivars) and... [more]

The oleaginous yeast Rhodosporidium toruloides has emerged as a robust host for production of microbial lipids as alternative biofuel feedstocks. Oxygen supply is a limiting factor for microbial lipid production, as lipid biosynthesis is highly oxygen-demanding. Vitreoscilla hemoglobin (VHb) is a protein capable of promoting oxygen delivery for anabolism. In this study, we developed R. toruloides with VHb expression for improved lipid production. The VHb expression cassette was integrated into the R. toruloides chromosome via the Agrobacterium-mediated transformation. In shake flask cultures, the engineered strain 4#-13 produced 34% more lipids than the parental strain did. Results obtained under reduced aeration conditions in 3 L bioreactor showed that lipid titer and lipid yield of the engineered strain 4#-13 were 116% and 71%, respectively, higher than those of the parental strain. Under high cell density culture conditions, the engineered strain 4#-13 grew faster and produced 72% m... [more]

A novel process is proposed whereby wood wastes from forest tree mortalities and improved forest management are co-digested with high in nitrogen content animal manures to yield bio-methane along with nitrogen, phosphorous, and potassium bio-fertilizers. The process mimics the well-known wood conversion to methane process in lower termites but relies on thermophilic fungi, bacteria, and archaea instead. It is based on the modified state-of-the art two-step, hyperthermophilic (70 °C) hydrolysis and thermophilic (55 °C) fermentation, dry (30% TS), anaerobic digestion technology with a high organic loading and shortened retention time. The process is augmented with the thermophilic fermentation of carbon dioxide in the biogas into secondary bio-methane by employing hydrogen produced via wind-powered electrolysis. The entire process comprised of five distinct steps is designated as “Wood to Methane 3 + 2”. An industrial type, standardized plant unit has been developed that can be employed... [more]

Crude oil is a major energy source that is exploited globally to achieve economic growth. To meet the growing demands for oil, in an environment of stringent environmental regulations and economic and technical pressure, industries have been required to develop novel oil salvaging techniques. The remaining ~70% of the world’s conventional oil (one-third of the available total petroleum) is trapped in depleted and marginal reservoirs, and could thus be potentially recovered and used. The only means of extracting this oil is via microbial enhanced oil recovery (MEOR). This tertiary oil recovery method employs indigenous microorganisms and their metabolic products to enhance oil mobilization. Although a significant amount of research has been undertaken on MEOR, the absence of convincing evidence has contributed to the petroleum industry’s low interest, as evidenced by the issuance of 400+ patents on MEOR that have not been accepted by this sector. The majority of the world’s MEOR field t... [more]

In the present work, sedimentary microbial fuel cells (s-MFC) have been proposed as effective tools to power remote sensors in different aquatic environments, thanks to their ability to produce renewable and sustainable energy continuously and autonomously. The present work proposes the optimization of cylindrical sedimentary microbial fuel cells (s-MFC) as a compact and cost-effective system suitable to be integrated as a payload in an Autonomous Underwater Vehicle (AUV). To this purpose, a new AUV payload, named MFC-payload, is designed to host the cylindrical s-MFC and a data acquisition system to collect and store information on the voltage produced by the cell. Its overall performance was evaluated during two field measurement campaigns carried out in the Mediterranean Sea. This investigation demonstrates the power production by s-MFC during operation of the AUV in seawater and analyzes the actual influence of environmental conditions on the output power. This study demonstrates t... [more]

Pandemics have presented new challenges for public transport organisers and operators. New diseases (e.g., influenza H1N1, severe acute respiratory syndrome—SARS, as well as, more recently, SARS-CoV-2) increase the need for new protection measures to prevent epidemic outbreaks in public transport infrastructure. The authors’ goal is to present a set of actions in the area of public transport that are adjusted to different levels of epidemic development. The goal goes back to the following question: how can the highest possible level of passenger safety be ensured and the losses suffered by urban public transport companies kept as low as possible? The sets of pro-active measures for selected epidemic scenarios presented in the article may offer support to local authorities and public transport operators. In the next steps, it is important to develop and implement tools for public transport management to ensure safety and tackle epidemic hazards.

Brewer’s spent grain (BSG), the solid residue of beer production, is attracting significant attention as raw material for the production of added value substances, since until recently it was mainly used as animal feed or deposited in landfills, causing serious environmental problems. Therefore, this work aimed at developing a bioprocess using BSG as a substrate for the production of cellulases and xylanases for waste saccharification and bioenergy production. Different fungi were analyzed for their cellulolytic and xylanolytic abilities, through a first screening on solid media by assessment of fungal growth and enzyme production on agar containing carboxylmethylcellulose or xylan as the sole carbon source, respectively. The best cellulase and xylanase producers were subjected to quantitative evaluation of enzyme production in liquid cultures. Aspergillus niger LPB-334 was selected for its ability to produce cellulase and xylanase at high levels and it was cultivated on BSG by solid s... [more]

The article aims to present results of research on anaerobic digestion (AD) of waste wafers (WF-control) and co-substrate system−waste wafers and cheese (WFC-control), combined with digested sewage sludge, as inoculum. The purpose of this paper is to confirm the outcome of adding silica/lignin (S/L; 4:1) material, as a microbial carrier, on the process performance and genetic diversity of microbial communities. The experiment was conducted in a laboratory under mesophilic conditions, in a periodical operation mode of bioreactors. Selected physicochemical parameters of the tested carrier, along with the microstructure and thermal stability, were determined. Substrates, batches and fermenting slurries were subjected to standard parameter analysis. As part of the conducted analysis, samples of fermented food were also tested for total bacterial count, dehydrogenase activity. Additionally, DNA extraction and next-generation sequencing (NGS) were carried out. As a result of the conducted st... [more]

This paper describes a two-cycle bacteria energy recovery system (BERS) to power two embedded sensors: an ultra-low portable pH sensor and a sound sensor. The designed unit can handle up to seven microbial fuel cells (MFCs) to charge a super-capacitor. This allows the BERS to provide a constant 0.14 mW without further electrical components for signal conditioning. The two cycles were driven with a 100 kΩ load and a 10 Hz frequency. The BERS is also self-powered with an integrated start-up unit to be self-activated when the MFCs charge the energy-storing unit after three days. The BERS powered pH sensor has an error below 5% at 25 ∘C and is able to work continuously while being activated for 4 h. The performances of the pH and sound sensors were determined based on a compromise between accuracy and power consumption.

The world increasingly requires biodegradable and renewable products in all production fields, with the vast volume of emissions generated by the fuel sector presenting a difficult issue that needs to be addressed [...]

Michael Potter pioneered microbial fuel cell (MFC) technology in 1911 [...]

Non-Alcoholic Fatty Liver Disease (NAFLD) is caused by the accumulation of fat in over 5% of hepatocytes in the absence of alcohol consumption. NAFLD is considered the hepatic manifestation of metabolic syndrome (MS). Recently, an expert consensus suggested as more appropriate the term MAFLD (metabolic-associated fatty liver disease). Insulin resistance (IR) plays a key role in the development of NAFLD, as it causes an increase in hepatic lipogenesis and an inhibition of adipose tissue lipolysis. Beyond the imbalance of adipokine levels, the increase in the mass of visceral adipose tissue also determines an increase in free fatty acid (FFA) levels. In turn, an excess of FFA is able to determine IR through the inhibition of the post-receptor insulin signal. Adipocytes secrete chemokines, which are able to enroll macrophages inside the adipose tissue, responsible, in turn, for the increased levels of TNF-α. The latter, as well as resistin and other pro-inflammatory cytokines such as IL-6... [more]

Hair follicles harbor a heterogeneous regenerative cell pool and represent a putative low-to-non-invasively available source of stem cells. We previously reported a technology for culturing human melanocytes from the hair follicle outer root sheath (ORS) for autologous pigmentation of tissue engineered skin equivalents. This study translated the ORS technology to horses. We de-veloped a culture of equine melanocytes from the ORS (eMORS) from equine forelock hair follicles cultured by means of an analogue human hair follicle-based in vitro methodology. The procedure was adjusted to equine physiology by addition of equine serum to the culture medium. The hair follicles were isolated by macerating forelock skin rests, enzymatically digested and subjected to air-medium-interface cultivation method. The procedure resulted in differentiated equine melanocytes, which exhibited typical morphology, presence of melanosomes, expression of cytoskeleton proteins vimentin, α-SMA, Sox2, S100ß and tyr... [more]

Continuous manufacturing opens up new operation windows with improved product quality in contrast to documented lot deviations in batch or fed-batch operations. A more sophisticated process control strategy is needed to adjust operation parameters and keep product quality constant during long-term operations. In the present study, the applicability of a combination of spectroscopic methods was evaluated to enable Advanced Process Control (APC) in continuous manufacturing by Process Analytical Technology (PAT). In upstream processing (USP) and aqueous two-phase extraction (ATPE), Raman-, Fourier-transformed infrared (FTIR), fluorescence- and ultraviolet/visible- (UV/Vis) spectroscopy have been successfully applied for titer and purity prediction. Raman spectroscopy was the most versatile and robust method in USP, ATPE, and precipitation and is therefore recommended as primary PAT. In later process stages, the combination of UV/Vis and fluorescence spectroscopy was able to overcome diffi... [more]

We previously developed a conjugate consisting of 10B cluster BSH and tri-arginine peptide (BSH-3R). This could potentially be used as a boron agent for boron neutron capture therapy; however, it possesses poor water solubility and thus needs to be improved for use as medicine. In this study, we devised several means of improving the water solubility of BSH-3R. As one of them, we used cyclodextrin (CD), which was expected to improve the water solubility resulting from interaction of the BSH-3R with CD. We evaluated the solubility of BSH-3R in aqueous CD solution by using reverse-phase high-performance liquid chromatography. As we expected, the solubility of BSH-3R was increased in a manner dependent on the addition of β-CD and γ-CD in aqueous solution. Furthermore, we synthesized BSH conjugated to oligoarginine having various chain lengths (BSH-nR) and BSH-3R with ethylene glycol linkers introduced between BSH and 3R (BSH-nEg-3R). The water solubility of these BSH peptides was also eva... [more]

Maize by-product from the bioethanol industry (distiller’s dried grains with solubles, DDGS) is a source of ferulated arabinoxylan (AX), which is a health-promoting polysaccharide. In the present study, AX from DDGS was fermented by a representative colonic bacterial mixture (Bifidobacterium longum, Bifidobacterium adolescentis, and Bacteroides ovatus), and the effect of the fermented AX (AX-f) on the proliferation of the cell line Caco-2 was investigated. AX was efficiently metabolized by these bacteria, as evidenced by a decrease in the polysaccharide molecular weight from 209 kDa to < 50 kDa in AX-f, the release of ferulic acid (FA) from polysaccharide chains (1.14 µg/mg AX-f), and the short-chain fatty acids (SCFA) production (277 µmol/50 mg AX). AX-f inhibited the proliferation of Caco-2 cells by 80−40% using concentrations from 125−1000 µg/mL. This dose-dependent inverse effect was attributed to the increased viscosity of the media due to the polysaccharide concentration. The... [more]

This paper investigates the optimum extraction temperature for enhanced total phenolic yields extracted from avocado fruit flesh (Persea americana) using subcritical water extraction, as well as the impact of fruit ripeness on phenol extraction efficiency. Additionally, extraction yield against extraction time was investigated for time intervals of 10 min over an overall extraction time of 30 min. The subcritical water conditions studied were 18 bar, 87 mL/min, and temperatures of 105 °C, 120 °C, and 140 °C. The total phenolic compounds content was compared for week one avocado flesh and ripe (week four) avocado flesh, with a four-week ripening period between the two samples. The results show that extracting with subcritical water at 105 °C provides the highest phenolic compounds yields of 0.11% and 0.26% by dried mass for week one and ripe fruit (week four), respectively. The experimental results also indicate that the implementation of lower extraction temperatures on week four avoca... [more]

The biodegradation of phenol, p-cresol, and phenol plus p-cresol mixtures was evaluated using Pseudomonas putida ATCC 17484 in aerobic batch reactors. Shake-flask experiments were performed separately using growth medium with initial nominal concentrations of phenol (50−600 mg L−1) and p-cresol (50−600 mg L−1) as well as phenol (50−600 mg L−1) plus p-cresol (50−600 mg L−1). The complete degradation of phenol and p-cresol was achieved within 48 h and 48−56 h, respectively, for all initial concentrations of phenol and p-cresol. The maximum cell growth rate using phenol (μmax,P = 0.45 h−1) was much faster than that using p-cresol (μmax,C = 0.185−1 h). The larger Ki value for phenol (310.5 mg L−1) revealed that the P. putida cells had a higher resistance to phenol inhibition compared with p-cresol (243.56 mg L−1). A mixture of phenol and p-cresol in batch experiments resulted in the complete removal of phenol within 52−56 h for initial phenol concentrations of 50−500 mg L−1. The time neede... [more]

Due to insufficient mass transfer and mixing issues, cells in the industrial-scale bioreactor are often forced to experience glucose feast/famine cycles, mostly resulting in reduced commercial metrics (titer, yield and productivity). Trehalose cycling has been confirmed as a double-edged sword in the Penicillium chrysogenum strain, which facilitates the maintenance of a metabolically balanced state, but it consumes extra amounts of the ATP responsible for the repeated breakdown and formation of trehalose molecules in response to extracellular glucose perturbations. This loss of ATP would be in competition with the high ATP-demanding penicillin biosynthesis. In this work, the role of trehalose metabolism was further explored under industrially relevant conditions by cultivating a high-yielding Penicillium chrysogenum strain, and the derived trehalose-null strains in the glucose-limited chemostat system where the glucose feast/famine condition was imposed. This dynamic feast/famine regim... [more]